Register
 (photo: Triton, Inc.)
02.09.2017, 03:25

Like Skin and Sunscreen

White Papers & Briefings

Dustin Brooks, Director of Sales at Triton Inc., explains why differences between coatings and membranes matter.

 

 

There's a difference between a coating and a membrane, and it can be hard to draw the line at times. In my professional opinion, I consider a roofing membrane to be your primary long-term, durable, and flexible barrier to prevent water and chemicals from damaging your insulation and entering your building. Going beyond roofing, let's look at the definition of a membrane. A membrane is a "pliable sheet-like structure acting as a boundary, lining, or partition in an organism."

 

The cells in your body have membranes separating the inside from the outside, protecting vital interior elements from damage. These cellular membranes are two layers (lipid bilayer) working together (this is where all fans of 2-ply, 4-ply, and 6-ply roof systems start cheering...redundancy starts at the cellular level!). Not all that different from a waterproofing membrane, serving as a pliable, long-term barrier between the structure and the elements.

 

So, what do I mean when I say a coating is not a membrane? Let's go back to the human anatomy analogy. Your skin is a membrane. It's tough, flexible, and virtually impermeable (you can sit in the bathtub for hours and get wrinkly, but your body doesn't blow up like a balloon...skin is only permeable to lipids and fat solvents). It protects the underlying tissues and organs from "the outside".

 

But if you're a naturally pale guy, like me, your skin is damaged when you're in the sun too long. Your sunscreen is a coating. The purpose of sunscreen is to protect your skin, the membrane, from damage. It's permeable, so you can still sweat, and it's applied relatively thin. Unless you're a lifeguard, then you put a nice thick layer of lotion on your nose. It doesn't last very long, so you'll need to re-apply. Alright, where am I going with this crazy analogy?

 

Liquid roofing products are not all that dissimilar. You have those that work great as a coating (sunscreen): applied in thin layers (20-30 mils), protect from UV degradation, permeable, cool you down (reflective), but need re-coated and touched up often. They do not perform like a membrane. They are not very durable, tough, flexible, or long-lasting. But they work great for protecting membranes! Think about it, what if your cells were only protected with a couple layers of acrylic paint?

 

Then you have other liquid products that work great as a membrane and end up like those made into rolls at a factory. Thick (50-80 mils), durable, flexible, strong, and impermeable. They serve as a primary barrier separating the structure from the elements. Some are reinforced, some are multi-layered, but the intended purpose is the same. No seams, fully-adhered, and self-terminating. These liquid-applied, seamless membranes should act more like your skin than your sunscreen.

 

The reason I write this article today is because all too often any material sold in a bucket or drum is labeled a "coating" and given the same negative stereotype. I've heard it often, "if it comes in a bucket, it sucks." But they don't all suck. With so many to choose from and filter through, it gets confusing and crowded. Here are a couple charts comparing the properties of both coatings and membranes, including the VOC content of each. Which ones would you rather have acting as a skin protecting your structure?

 

 

 

article Rating

vote data

leave Reply

Dirk Bremm. (photo: BASF SE)
BASF SE  - 03.04.2017, 17:44

New President for BASF’s Coatings Division

BASF confirms the appointment of Dirk Breem as president of its Coatings division on 1 April. He succeeds Dr. Markus Kamieth who has joined the Board of Executive Directors of BASF SE.

Warehouse safety flooring. (photo: Stonhard UK)
Stonhard (UK) Ltd  - 01.04.2017, 16:35

Industrial Flooring Installation

Jarden Plastic Solutions (JPS) who operate from a 5,500 square metre site in Christchurch, Dorset, have selected Stonhard UK to supply and install industrial flooring during the expansion of their...

View of the Shah Jahan Mosque and its spectacular dome. (photo: Belzona International)
Belzona International  - 27.03.2017, 16:52

Case-study: Dome and Dusted

Composite roof coatings were used for the refurbishment of the Grade II listed Shah Jahan Mosque in Woking which is the oldest in Western Europe.

 (photo: Confida FM)
Confida FM  - 02.06.2017, 17:12

New Beginnings for Ayrshire FM Business

The launch of Confida FM promises a bright new future for a wife and husband management team - and the facilities management industry in Scotland...and beyond.

 (photo: WPS Parking Systems BV)
WPS Parking Systems BV  - 15.03.2017, 14:04

Next-generation Parking Technology for Celtic Manor

WPS, one of the UK’s leading parking equipment manufacturers, has won a second contract to provide its ParkAdvance™ technology at the prestigious Celtic Manor Resort in Newport.

 (photo: Infomill Ltd)
Infomill Ltd  - 09.01.2017, 12:22

New Version of PartsArena Pro App

Heating engineers across the UK will enjoy a new, updated version of PartsArena Pro from January 2017 as creator, Infomill rolls out its latest improvements to the leading source of heating parts...

Crocus on site. (photo: Bodet Ltd.)
Bodet Ltd  - 22.09.2016, 20:30

Nursery and Garden Produce Staff Go Biometric

Leading nursery and online garden produce retailer Crocus have just installed the very latest Bodet interactive time and attendance system, to provide accurate and reliable staff attendance data...